Manuale d’uso / di manutenzione del prodotto EFP33NRB del fabbricante Desa
Vai alla pagina of 48
Sav e this manual for future reference. For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol- lowed exactly , a fire or explosion may result causing property damage, personal injury or loss of life.
www .desatech.com 1 1 1245-01B 2 W ARNING: Improper installation, adjustment, altera- tion, service or maintenance can cause injury or prop- erty damage. Refer to this manual for correct installation and operational procedures. For assistance or addi- tional information consult a qualified installer , service agency or the gas supplier .
www .desatech.com 1 1 1245-01B 3 SAFETY INFORMA TION WA RNIN G: T hi s pro du ct c on - ta ins an d/o r ge ner ate s ch emi cal s kno wn to the state of California to cause cancer or birth defects or other reproductive harm.
www .desatech.com 1 1 1245-01B 4 1. This ap plia nce is only for us e wi th t he type of ga s indi ca ted on the rat ing plat e. This appl ian ce is n ot conv erti ble for use wit h ot her gas es. 2. Do not place propane/LP supply tank(s) in - side any structure.
www .desatech.com 1 1 1245-01B 5 LOCAL CODES Install and use fireplace with care. Follow all local codes. In the absence of local codes, use the lat- est edition of The National Fuel Gas Code, ANSI Z223.1/NFP A 54 *. *A vailable from: American National Standards Institute, Inc.
www .desatech.com 1 1 1245-01B 6 AIR FOR COMB USTION AND VENTILA TION W ARNING: This heater shall not be installed in a confined space or unusually tight con - struction unless provisions are provided for adequate combus- tion and ventilation air .
www .desatech.com 1 1 1245-01B 7 AIR FOR COMB USTION AND VENTILA TION Continued 1. Dete rmin e th e vo lume of the spac e (l engt h x width x height). Length x Width x Height =__________cu. ft. (volume of space) Example: Space size 20 ft. (length) x 18 ft.
www .desatech.com 1 1 1245-01B 8 V entilation Air From Outdoors Prov ide extra fresh air by using ventilat ion grills or ducts. Y ou must provide two permanent openings: one within 12" of the ceiling and one within 12" of the floor . Connect these items directly to the outdoors or spaces open to the outdoors.
www .desatech.com 1 1 1245-01B 9 WARNING: This appliance is equipped for (natural or pro- pane/LP) gas. Field conversion is not permitted. ELECTRICAL HOOKUP T h i s fi r e pl ac e n or ma l ly op er a te s u n d e r 12 0 V AC/60 Hz line voltage. The electrical cord sup - plied with your fireplace is five feet in length.
www .desatech.com 1 1 1245-01B 10 3. Remove screws that attach fireplace floor as- sembly to fireplace. Open lower louver door . Carefully lift up fireplace floor assembly and rem ove f rom fi rep lac e, ta kin g car e to pu ll flexible gas line through the access holes (see Figure 6).
www .desatech.com 1 1 1245-01B 1 1 INST ALLA TION Continued Note: If you choose to relocate the wall switch assembly , do so before final installation into a mant el or reces sing into a wall. If you are instal ling an optional blower accessory , install it at the same time you relocate the wall switch assembly .
www .desatech.com 1 1 1245-01B 12 4 3 / 4 " 3 3 / 4 " 3/8" 3/16" 3/4" 3/8" Diameter 2 Holes 8. Remove paper template from wall. 9. Drill 3/8" holes at each mark. 10. Using a straight edge and pencil, connect the oute r edges of the 4 hole s for the recta ngle (see Figure 10).
www .desatech.com 1 1 1245-01B 13 13. Position wall switch assembly vertically over opening with decal lettering upright. Make sure wires freely pass through wall without binding. Align holes in wall plate with 1/8" pilot holes in mantel wall. 14.
www .desatech.com 1 1 1245-01B 14 9. Check to make sure that all electrical cords are completely clear of the blower wheel and that there are no other foreign objects in blower wheel. Turn blower on and check for operation. Turn blower off by rotating knob fully counterclockwise before continuing.
www .desatech.com 1 1 1245-01B 15 INST ALLING THERMOST A TIC BLOWER ACCESSOR Y NOTICE: Shut off gas supply and disconnect heater from gas supply if installing blower in previously installed fireplace. Contact a qualified service per- son to do this.
www .desatech.com 1 1 1245-01B 16 INST ALLA TION Continued W ARN ING : Fa il ur e t o co nn ec t all wires prop erl y as indi cat ed ma y cau se e le ctr ical shor t cir cu it or per son al inju ry . A qu ali fied ele ctr ici an shoul d c hec k tha t all con nec tio ns are ma de pro per ly .
www .desatech.com 1 1 1245-01B 17 16. Re a t t a c h f i r e p l a c e fl o o r a s s e m b l y w i t h screws removed in step 3 of Removing Fir e - place Screen and Floor Assembly , page 9. Note: Discard the remaining hardware items. After assembly , make sure all wires are com - pletely clear of blower wheel.
www .desatech.com 1 1 1245-01B 18 CAUT ION: Use o nly ne w , black iron or steel pipe. Inter- nally-tinned copper tubing may be used in certain areas. Check your local codes. Use pipe of 1/2" diameter or greater to allow proper gas volume to fireplace.
www .desatech.com 1 1 1245-01B 19 3. Attach the flexible gas line to gas supply (see Figure 26). Check tightness of flexible gas line attached to gas regulator of fireplace (see Figure 26). 4. Check all gas connections for leaks. See Checking Gas Connections .
www .desatech.com 1 1 1245-01B 20 PRESSURE TESTING FIREPLACE GAS CONNECTIONS 1. Open equipment shutof f valve (see Figure 27, page 19). 2. Open main gas valve located on or near gas meter for natural gas or open propane/LP supply tank valve. 3. Pl a ce m an u a l i g ni t i on s wi t ch i n t h e O F F position.
www .desatech.com 1 1 1245-01B 21 5. Route flexible gas line through access hole in hearth base. 6. Ce nte r ca bi net ma nt el on he a rt h bas e (se e Fi gu re 31) . Mak e sur e man tel i s flus h aga in st wa ll. 7. Break off nailing flanges (see Figure 32) with hammer or pliers.
www .desatech.com 1 1 1245-01B 22 3. If not already completed, install gas piping to firep lace loca tion . This insta lla tion incl udes an approved flexible gas line (if allowed by local codes) after the equipment shutof f valve. The flexible gas line must be the last item installed on the gas piping.
www .desatech.com 1 1 1245-01B 23 Figure 37 - Minimum Mantel Clearances for Built-In Installation Supplied Firebox Hood Must Be Used at All Times Wire-mesh Screen Firebox Noncombustible Material May P.
www .desatech.com 1 1 1245-01B 24 INST ALLING LOGS W AR NIN G: Fai lur e t o po si tio n t h e pa rt s in ac c o r da nc e wi t h th es e di agr ams o r fa ilu re to us e onl y pa rts sp eci fica lly a pp rov ed wi th th is he at er may re sul t i n pr op ert y da mag e o r p ers ona l i nju ry .
www .desatech.com 1 1 1245-01B 25 Figure 44 - Installing Crossover Logs (#4 & #5) [CGEFP Logs Shown] Pins Crossover Log (#5) Crossover Log (#4) INST ALLING BA TTERY INTO REMOTE 1.
www .desatech.com 1 1 1245-01B 26 NORMAL LIGHTING INSTRUCTIONS W ARNING: Y ou must oper- ate this heater with the fireplace screen in place. Make sure fire- place screen is in place before running heater . N OT IC E : Du r i n g in i t ia l o p e ra t i o n of n e w he at er , b ur ni ng l o g s wi ll gi ve o f f a pa pe r- bu rn in g sm el l.
www .desatech.com 1 1 1245-01B 27 Note: Y ou may be running this heater for the first time after connecting to gas supply or at the start of your heating season. If so, the ON button may need to be pressed again. This will allow air to bleed fr om gas syst em.
www .desatech.com 1 1 1245-01B 28 OPERA TING FIREPLACE Continued TO TURN OFF GAS TO APPLIANCE Shutting Off Heater When Manually Lit S et ma n ua l i gn it io n by pa s s sw it c h o n co nt r ol pa ne l to OFF (a uto mati c ign itio n pos itio n) . Th is will ca use th e c ont ro ls to sh ut dow n t he fir epl ac e .
www .desatech.com 1 1 1245-01B 29 CLEANING AND MAINTENANCE W ARNING: T urn off fireplace and let cool before cleaning. CAUTION: Y ou must keep control areas, burners and circulating air passageways of fireplace clean. In spect these areas of fireplace before each use.
www .desatech.com 1 1 1245-01B 30 TROUBLESHOO TING W ARNING: T urn off heater and let cool before servicing. Only a qualified service person should service and repair heater . CAUTION: Never use a wire, needle or similar object to clean ODS/pilot. This can damage ODS/pilot unit.
www .desatech.com 1 1 1245-01B 31 OBSERVED PROBLEM Slight smoke or odor during initial operation Moisture/condensation noticed on windows Heater produces a whistling noise when burner is lit When igni.
www .desatech.com 1 1 1245-01B 32 TROUBLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone.
www .desatech.com 1 1 1245-01B 33 OBSERVED PROBLEM Gas odor during combustion Dark residue on logs or inside of fireplace Note: After removing all causes of residue deposits, completely clean fireplace and appliances of all residue before reusing appliance.
www .desatech.com 1 1 1245-01B 34 13 24 42 43 25 44 40 14 32 31 12 1 1 8 4 2 1 3 39 6 28 27 7 14 16 46 47 33 15 19 38 29 34 21 22 20 36 37 10 18 30 35 23 26 17 9 41 45 5 ILL USTRA TED P ARTS BREAKDOWN.
www .desatech.com 1 1 1245-01B 35 P ARTS LIST REMOTE CONTROL LOG BASE ASSEMBL Y This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 40 of this manual. KEY P ART NUMBER NO.
www .desatech.com 1 1 1245-01B 36 13 24 42 43 25 44 40 14 32 31 12 1 1 8 4 2 1 3 39 6 28 27 7 14 16 46 47 33 15 19 38 29 34 21 22 20 36 37 10 18 30 35 23 26 17 9 41 45 5 ILL USTRA TED P ARTS BREAKDOWN.
www .desatech.com 1 1 1245-01B 37 P ARTS LIST REMOTE CONTROL LOG BASE ASSEMBL Y This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 40 of this manual. KEY P ART NUMBER NO.
www .desatech.com 1 1 1245-01B 38 ILL USTRA TED P ARTS BREAKDOWN FI REB OX MO DE LS CG EFP 33 PRB , CG EFP 33 NRB , EFP 33 PRB AN D EFP 33 NRB 1 2 3 4 10 16 8 1 1 14 14 14 6 7 12 14 14 13 5 14 9 9 19 .
www .desatech.com 1 1 1245-01B 39 P ARTS LIST FI REB OX MO DE LS CG EFP 33 PRB , CG EFP 33 NRB , EFP 33 PRB AN D EFP 33 NRB This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 40 of this manual.
www .desatech.com 1 1 1245-01B 40 ACCESSORIES Purchase these fireplace accessories from your local dealer or Parts Central (see page 43). If they can not supply these accessories, call DESA Heat - ing Products at 1-866-672-6040 for information. Y ou can also write to the addres s listed on the back page of this manual.
www .desatech.com 1 1 1245-01B 41 LO PILO T OFF HI ACCESSORIES Continued CORNER MANTEL AND BASE ACCESSOR Y WITH FIREPLACE PERIMETER TRIM (Not Shown) CMA303 Series - Unfinished Oak V eneer , Ready to Stain or Paint For all models . Space saving corner mantels feature moldings, fluting and medallion.
www .desatech.com 1 1 1245-01B 42 WIRING DIAGRAM Note: For proper operation, the wires must be connected exactly as shown in wiring diagram. See pages 35 or 37 for number key .
www .desatech.com 1 1 1245-01B 43 TEMPLA TES 4 3 / 4 " 4 3 / 4 " 3 3 / 4 " 3/8" 3 3 / 4 " 3/8" 3/16" 3/4" 3/4" 3/8" Diameter 2 Holes 1/8" Diamete.
www .desatech.com 1 1 1245-01B 44 THIS P AGE INTENTION ALL Y LEFT BLANK.
www .desatech.com 1 1 1245-01B 45 P ARTS CENTRAL These Parts Centrals are privately owned businesses. They have agreed to support our customer ʼ s needs by providing original replacement parts and accessories. W asher Equipment Co. 1715 Main Street Kansas City , MO 64108-2195 KS, MO, AR 816-842-391 1 www .
www .desatech.com 1 1 1245-01B 46 ______________________________________________________ ______________________________________________________ ______________________________________________________ _.
www .desatech.com 1 1 1245-01B 47 NO TES ______________________________________________________ ______________________________________________________ _________________________________________________.
2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com 1 1 1245-01 Rev . B 09/04 NOT A UPC 111245 01.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Desa EFP33NRB è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Desa EFP33NRB - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Desa EFP33NRB imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Desa EFP33NRB ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Desa EFP33NRB, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Desa EFP33NRB.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Desa EFP33NRB. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Desa EFP33NRB insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
