Manuale d’uso / di manutenzione del prodotto LH358EA del fabbricante Tecumseh
Vai alla pagina of 24
Operator’s Manual LH318XA (HM80-100) LH358EA/LH358XA Four-Cycle Engine • L-Head • Horizon tal Cra nkshaft • Air- Cooled T able of Content s IMPORTANT NOTICE! Sa fety Definitions ...................................... ii I. General Safety Precautions .
Page ii Four-Cycle Engine • L-Head • Horizo ntal Crankshaft • Air-Cooled 181-630- 14 IMPORT ANT NOTICE! Safety Definitions Statements in this manual preceded by the following wor ds and graphics.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 1 I. General Safety Precautions ! W ARNING A. A void Carbon Monoxide Poisoning All engine exhaust contain s carbon monoxide, a dead ly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, co nfusion and eventually death.
Page 2 Four-Cycle Engine • L-Head • Horizontal Cranksh aft • Air -Cooled 181- 630-14 E. DO NOT Modify Engine To avoid serio us in jury or de ath, DO NOT mo dify engine in any way. Tampering with the governor setting can lead to a runaway engine and cause it to operate at unsa fe speeds.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 3 II. How to Get Service For engine adjustme nts, r epairs or warranty service NOT covere d in this manu al, contact y our nearest Authorized Te cumseh Power Servicing Dealer.
Page 4 Four-Cycle Engine • L-Head • Horizontal Cranksh aft • Air -Cooled 181- 630-14 III. Oil and Fuel S pecifications A. Oil To operate engine you ne ed to use a clean, high quality, detergent oil. Fo r recommended en gine oil, see Table 1. In addition, you need to be sure the oil su mp contains the correct amount of oil to operate properly.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 5 B. Filling Oil Sump 1. Be sure engine is upright and level. 2. Unscrew oil fill cap/ dipstick from oil filler tube and wipe dipstick clean . See Figure 8. 3. Screw oil fill cap/dipstick back into oil filler tube.
Page 6 Four-Cycle Engine • L-Head • Horizontal Cranksh aft • Air -Cooled 181- 630-14 E. Low Oil Shut down Light Some engines are equip ped with an optional Low Oil Shutdown System that includes a light but does not include a rocker switch.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 7 H. Climate Guard ® Air Cleaner Some engines are equipped with an optional Climate Guard Air Cleaner or Climate Guard.
Page 8 Four-Cycle Engine • L-Head • Horizontal Cranksh aft • Air -Cooled 181- 630-14 V . St arting Y o ur Engine An adult should start the engine. Only allow children to st art engine if an adult has de termined they a re experienced and capable of such operation.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 9 6. When engine sta rt s: a. Release starter bu tton or ignition switch key . b. Momentar ily move choke control to “1/2 CHOKE” position until engine runs smoo thly .
Page 10 Four-Cycle Engine • L-Head • Horizo ntal Crankshaft • Air-Cooled 181-630- 14 B. Engines with Recoil St arters 1. T o avoid carbon monoxide poisoning , be sure engine is outdoors in a well-ventilated area.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 11 When pulling st ar ter rope, the rope can unexpe ctedly jerk bac k toward engine causin g ser iou s inju ry . T o avoid this risk, carefully follow these instructions: 5.
Page 12 Four-Cycle Engine • L-Head • Horizo ntal Crankshaft • Air-Cooled 181-630- 14 VI. S topping Y our Engine and Short-T erm S torage Stop engine according to equipment manufa cturer’s instructions. To avoid unsupervised op er ation of an engine, especially by children, NEVER leave it unattended when it is running.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 13 B. Removing Debris from Engine Before each use, remove grass clippings, dirt and debris from the following ar.
Page 14 Four-Cycle Engine • L-Head • Horizo ntal Crankshaft • Air-Cooled 181-630- 14 III. Filter Removal/Inst allation 1. Remove wing nut. See Figure 32 or 33. 2. Remove cover . 3. Remove foam pre-filter , if present (see equip ment manufacturer’s instructions) from ou t side of p ape r filter .
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 15 VIII. T ransporting Y our Engine NEVER transport this engine inside another vehicle or in any enclosed space if there is any gasoline in the tank. Fuel vapor or spilled fuel may ignite.
Page 16 Four-Cycle Engine • L-Head • Horizo ntal Crankshaft • Air-Cooled 181-630- 14 III. Fuel System To avoid stale gas and car buretor problems, treat the fuel system in the following method b.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 17 IV . Oil Cylinder Bore When lubricatin g cylinder bor e, fuel may spray from spar k plug hole. To prevent se rious injury fro m fuel fires, follow these instructions: 1.
Page 18 Four-Cycle Engine • L-Head • Horizo ntal Crankshaft • Air-Cooled 181-630- 14 XI. Maintenance Intervals Maintenance is on e of th e mo st impo rt an t thin g s tha t you can do to extend the lif e of your T ecumsehPower engine.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 19 Every 100 Hours or Seasonally 1. Replace Paper Filter 2. Check Sp ark Plug Date____________ ___Owner/Dealer D.
Page 20 Four-Cycle Engine • L-Head • Horizo ntal Crankshaft • Air-Cooled 181-630- 14 CALIFORNIA & US EP A EMISSION CONTROL W ARR ANTY ST ATEM ENT The U.
181-630-14 F our-Cycle Engine • L-Head • Horizontal Cra nkshaft • Air-Cooled Page 21 EMISSION CONTROL SYSTEM W ARRANTY Emission Control System Warr anty (“ECS Warranty”) for 1995 and later model year California sma ll off-road engines (for other states, 1997 and later model year engi nes): A .
T ecumsehPower Company • Grafton, Wisconsin 53024-1499 • USA Telephone: 1-800-558-5402 Visit us at: www.TecumsehPo wer.com 181-630-14 (English) 6/01/08 WA R N I N G ! CALIFORNIA PROPOSITION 65 reproductive harm.
Un punto importante, dopo l’acquisto del dispositivo (o anche prima di acquisto) è quello di leggere il manuale. Dobbiamo farlo per diversi motivi semplici:
Se non hai ancora comprato il Tecumseh LH358EA è un buon momento per familiarizzare con i dati di base del prodotto. Prime consultare le pagine iniziali del manuale d’uso, che si trova al di sopra. Dovresti trovare lì i dati tecnici più importanti del Tecumseh LH358EA - in questo modo è possibile verificare se l’apparecchio soddisfa le tue esigenze. Esplorando le pagine segenti del manuali d’uso Tecumseh LH358EA imparerai tutte le caratteristiche del prodotto e le informazioni sul suo funzionamento. Le informazioni sul Tecumseh LH358EA ti aiuteranno sicuramente a prendere una decisione relativa all’acquisto.
In una situazione in cui hai già il Tecumseh LH358EA, ma non hai ancora letto il manuale d’uso, dovresti farlo per le ragioni sopra descritte. Saprai quindi se hai correttamente usato le funzioni disponibili, e se hai commesso errori che possono ridurre la durata di vita del Tecumseh LH358EA.
Tuttavia, uno dei ruoli più importanti per l’utente svolti dal manuale d’uso è quello di aiutare a risolvere i problemi con il Tecumseh LH358EA. Quasi sempre, ci troverai Troubleshooting, cioè i guasti più frequenti e malfunzionamenti del dispositivo Tecumseh LH358EA insieme con le istruzioni su come risolverli. Anche se non si riesci a risolvere il problema, il manuale d’uso ti mostrerà il percorso di ulteriori procedimenti – il contatto con il centro servizio clienti o il servizio più vicino.
